Bauer Compressors B-RFID RF ID Reader in Air Fill Station User Manual Part 3
Bauer Compressors, Inc RF ID Reader in Air Fill Station Users Manual Part 3
Contents
- 1. Users Manual Part 1
- 2. Users Manual Part 2
- 3. Users Manual Part 3
- 4. Users Manual Part 4
Users Manual Part 3
| Download: |  |
| Mirror Download [FCC.gov] | |
| Document ID | 3702624 |
| Application ID | M1z6mN3GTIiSX5QviVu0zA== |
| Document Description | Users Manual Part 3 |
| Short Term Confidential | No |
| Permanent Confidential | No |
| Supercede | No |
| Document Type | User Manual |
| Display Format | Adobe Acrobat PDF - pdf |
| Filesize | 354.52kB (4431469 bits) |
| Date Submitted | 2018-01-04 00:00:00 |
| Date Available | 2018-01-04 00:00:00 |
| Creation Date | 2017-12-14 17:13:47 |
| Producing Software | Foxit PhantomPDF Printer Version 8.3.1.0522 |
| Document Lastmod | 2017-12-14 17:13:47 |
| Document Title | Users Manual Part 3 |
MNL-0021 Figure 3-49 Item Qty Part No. Description Notes UNICUS 4i 3.3.2 Trouble shooting Trouble Cause Remedy MNL-0021 CHAPTER 4: PURIFICATION SYSTEM 4.1 Introduction WARNING 4.1.1 General Purification System Procedures 4.1.2 Chamber Safety Bore UNICUS 4i Figure 4-1 Figure 4-2 Safety Vent (leaking) Safety Vent (no leak) Safety Vent No Cartridge Installed or Installed incorrectly Cartridge Installed correctly Safety Ve nt C ar tridge In sta lled C or rectl y No Car tridge o r Instal led Incor rectl y 4.1.3 Manual Condensate Drainage 4.1.4 Model, Serial Number and Part Number Identification 4.1.4.1 Figure 4-3 PUR IFIC ATION SYSTEM CARTRIDGE TO BE INSTALLED MODEL NO . MAX . PRESSURE psig CARTRIDGE FOR AIR PROC ESSED cu. ft. CARTRIDGE NO. O-RING 132 8 Azale a Ga rden R oad - Norfolk Virginia 235 02-1 944 Ph one : (757) 855-6006 Fa x: (757) 85 5-82 24 BACK- UP RIN G LBL-0191 LBL-0044 MNL-0021 4.1.4.2 4.1.4.3 4.1.5 Purification System Configurations Purification System Number and Type of Cartridges Dryer Purification Securus® Processing Capacity cubic ft (ft)3 UNICUS 4i 4.1.6 Industrial Purification System Configurations Purification System Number and Type of Cartridges Dryer 4.1.7 Cartridge Operating Life Purification Securus® Processing Capacity cubic ft (ft)3 MNL-0021 4.1.7.1 4.1.7.2 UNICUS 4i Figure 4-4 Figure 4-5 10/19/04 92°F (33 °C) 0.5 16.00 11/01/04 45°F (7.2 °C) 2.25 1.78 Op hrs Corr. factor 16.00 Total hrs +Today hr s 17.78 MNL-0021 4.1.7.3 Date Operating hours Ambient temp. + 18°F during compression Correction factor Adjusted cartridge hours Today Total UNICUS 4i 4.2 1P5S Securus II Purification System 4.2.1 P5S Securus II Purification System Major Components Figure 4-6 MNL-0021 4.3 Component Description 4.3.1 Oil and Water Separator WARNING Figure 4-7 4.3.2 Chamber 4.3.3 Cartridge 4.3.3.1 UNICUS 4i 4.3.3.2 Purification Cartridge 4.3.4 Condensate Drain Valve 4.3.5 Check Valves Protective Cap 4.3.6 Bleed Valve 4.3.7 Pressure Maintaining Valve 4.3.8 Safety Valve 4.3.9 Securus II Electronic Moisture Monitor System 4.3.9.1 4.3.9.2 MNL-0021 4.4 Maintenance 4.4.1 Oil and Water Separator UNICUS 4i Figure 4-9 Figure 4-8 MNL-0021 4.4.1.1 Figure 4-10 NOTICE 4.4.2 Cartridge Replacement Figure 4-11 UNICUS 4i 4.4.2.1 NOTICE MNL-0021 4.5 Replacement Parts List Figure 4-12 Item Qty Part No. Description Notes 1 gauge stock, 2nd is optional UNICUS 4i Figure 4-13 Item Qty Part No. Description Notes MNL-0021 Figure 4-14 Item Qty Part No. Description Notes UNICUS 4i Figure 4-15 18 17 16 15 14 13 12 11 10 Item Qty Part No. Description Notes MNL-0021 Figure 4-15 (cont.) Item Qty Part No. Description Notes UNICUS 4i CHAPTER 5: COMPRESSOR DRIVE; UNICUS 4I 5.1 Vertical Compressor Drive Figure 5-1 5.2 Maintenance of the V-belt and Sheaves 5.2.1 Check The Sheaves. MNL-0021 5.2.2 Check the V-belt Figure 5-2 Figure 5-3 5.2.3 Replacing the Belt NOTICE 5.2.4 Replacing the Sheave UNICUS 4i 5.3 Replacement Part List Figure 5-4 Item Qty Part No. Description UNICUS 4i - 25 Notes MNL-0021 CHAPTER 6: ELECTRICAL PANEL, ASY-1191 6.1 Overview Figure 6-1 6.2 Electrical Panel 6.2.1 Wiring Diagram 6.2.2 Electrical Panel Interior Access UNICUS 4i 6.3 AC Power Requirements Figure 6-2 6.4 Electrical Panel Components 6.4.1 Programmable Logic Controller (PLC) Figure 6-3 MNL-0021 Figure 6-4 6.4.1.1 6.4.1.2 UNICUS 4i 6.4.1.3 6.4.2 Hour Meter Figure 6-5 6.4.3 Motor Starter. MNL-0021 6.4.4 Overload Relay Figure 6-6 Figure 6-7 6.4.5 Power Supply Figure 6-8 UNICUS 4i 6.5 Alarms 6.5.1 Final Separator Warning Table 6-1: Maximum Compressor Pressure Warning WARNING 6.5.2 Compressor High Temperature Figure 6-9 Figure 6-10 Shutdown MNL-0021 6.5.3 Compressor Low Oil Pressure OIL PRESS TD UNICUS 4i 6.6 Replacement Parts List Figure 6-11 Item Qty Part No. Description Notes MNL-0021 Figure 6-11 (cont.) Item Qty Part No. Description Notes UNICUS 4i CHAPTER 7: RFID OPTION 7.1 Description NOTICE 7.2 Components Figure 7-1 MNL-0021 7.3 Functions 7.3.1 Assigning the Cylinder Figure 7-2 7.3.2 Filling the Cylinder with RFID Option UNICUS 4i 7.4 Replacement Parts List Figure 7-3 Item Qty Part No. Description Notes MNL-0021 CHAPTER 8: ENMET GAS MONITORS 8.1 Description Figure 8-1 8.2 Operation Sensor UNICUS 4i Figure 8-2 Figure 8-3 8.3 Calibration MNL-0021 8.4 Sensor Replacement UNICUS 4i 8.5 Replacement Parts Figure 8-4 Item Qty Part No. Description Notes 8 10 UNICUS 4i Figure 8-5 Item Qty Part No. Description Notes MNL-0021 Figure 8-5 (cont.) Item Qty Part No. Description Notes UNICUS 4i Figure 8-6 Item Qty Part No. Description Notes MNL-0021 Figure 8-7 Item Qty Part No. Description Notes
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.7 Linearized : No Page Count : 45 Warning : Duplicate 'Im39' entry in dictionary (ignored) Author : Create Date : 2017:12:14 17:13:47-06:00 Creator : Modify Date : 2017:12:14 17:13:47-06:00 Producer : Foxit PhantomPDF Printer Version 8.3.1.0522 Subject : Title :EXIF Metadata provided by EXIF.tools